7-party emulsified asphalt spreader

  • Applications for asphalt emulsions | Asphalt magazine

    In a single chip seal, an asphalt emulsion is sprayed on the pavement with a distributor, then immediately covered by a single layer of uniformly sized chips from a chip spreader. A double chip seal repeats the procedure using lower emulsion and aggregate application rates.

    Get Price

  • UFGS 32 01 13.63 Gilsonite Modified Asphalt Emulsion Seal ...

    The distributor must be equipped to hand spray the emulsion in areas identified either on the plans or by the Contracting Officer. 1.3.3 Aggregate Spreader The asphalt distributor truck will be equipped with an aggregate spreader that can apply sand to the emulsion in a single pass operation without driving through wet emulsion.

    Get Price

  • Section 427 Emulsified Asphalt Slurry Seal

    Emulsified asphalt slurry seal is used to seal small cracks and correct moderate surface condition. Apply this type at a rate of 10 to 20 lbs/yd² (5.5 to 11 kg/m²) based on dry aggregate weight. If more than 20 lbs/yd² (11 kg/m²) of emulsified asphalt slurry seal is …

    Get Price

  • TYPE I EMULSIFIED ASPHALT SLURRY SEAL SURFACE …

    The slurry seal shall consist of a mixture of an approved emulsified asphalt, mineral aggregate, water and specified additives, proportioned, mixed and uniformly spread over the properly prepared surfaces of Runway 3/21 and the Taxiway/Apron as directed by the Jackson County Administrator.

    Get Price

  • Pavement Preservation - Bergkamp Inc.

    About Slurry Seal & Microsurfacing. The main difference between slurry seal and micro surfacing is that slurry seal uses a standard asphalt emulsion which requires evaporation to occur and sets in several hours. Micro surfacing uses a polymer-modified asphalt emulsion that produces a chemical reaction to force the moisture out...

    Get Price

  • z~a~~ - resources.vtrans.vermont.gov

    Use of an MC-3000 cutback asphalt in place of the emulsion for the identical treatment would cost 9% more, use 241% more energy and produce considerable hydrocarbon air pollution.

    Get Price

  • SBR Latex Modified Emulsified Asphalt

    The emulsified asphalt binder shall not be applied until the loaded aggregate spreader is on hand ready to begin application of aggregate immediately, with sufficient truck loads of aggregate at the site to cover the length of the anticipated applications of emulsified asphalt binder.

    Get Price

  • Asphalt Distributor Trucks & Asphalt Emulsions Sprayers

    Asphalt Distributor Trucks & Trailers. 2000 Gallon Asphalt Distributor Skid Mounted, STRATOS asphalt distributor, Fully Insulated, Dual Burner, chassis mount frame option available 518-218-7676 Engineered and designed for spraying emulsion products such as CSS-1h, CRS-2, MC-250, HFRS-2 and the full range of emulsion products.

    Get Price

  • Bitumen Spreader, Bitumen Spreader Suppliers and ...

    Alibaba.com offers 804 bitumen spreader products. About 45% of these are pavers, 7% are other construction machinery, and 1% are fertilizer spreaders. A wide variety of bitumen spreader options are available to you,

    Get Price

  • Asphalt Spreader, Asphalt Spreader Suppliers and ...

    New mode Yuejin 5m3 asphalt spreader Asphalt distributor is a highly precise measuring asphalt spreader . It is often used to road construction and maintenance of bridges ,highways ,tunnels ,airports,country roads work. Asphalt distributor truck adopts asphalt spray bar fixed value display device ,nozzle auto-control device ,etc.

    Get Price

  • UFGS 32 01 13.63 Gilsonite Modified Asphalt Emulsion Seal ...

    1.3.3 Aggregate Spreader The asphalt distributor truck will be equipped with an aggregate spreader that can apply sand to the emulsion in a single pass operation without driving through wet emulsion. The aggregate spreader must be equipped with a variable control system capable of …

    Get Price

  • Asphalt Paver Rentals | Cat Rental Store

    Asphalt Pavers for Rent at Your Local Cat® Rental Store. Get it here. This site uses and sets "cookies" on your computer to help make this website better. You can learn more about these cookies and general information about how to change your cookie settings by clicking here. By continuing to use this site without changing your settings, you ...

    Get Price

  • TYPE I EMULSIFIED ASPHALT SLURRY SEAL SURFACE …

    2.3 EMULSIFIED ASPHALT- The emulsified asphalt shall confirm to the requirements of ASTM D 977 and/or 2397 and shall be SS, CSS, CQS, or QS type emulsions. 2.4 WATER- All water used in making the slurry shall be potable and free from harmful soluble salts and chemicals. Type I Slurry Seal Surface Treatment Page 3

    Get Price

  • AGGREGATE SEAL COAT TECHNICAL SPECIFICATIONS

    AGGREGATE SEAL COAT TECHNICAL SPECIFICATIONS ... 1.2 The polymer modified emulsified asphalt seal coat shall be constructed in accordance with these specifications and in conformity to the lines, grades, thickness and cross sections shown ... 3.4 Aggregate Spreader: The aggregate spreader shall be a self-propelled mechanical spreader, ...

    Get Price

  • VIRGINIA DEPARTMENT OF TRANSPORTATION SPECIAL …

    A. Asphalt Emulsion: Emulsified asphalt shall conform to the requirements of Section 210 of the Specifications; except it shall be a quick setting emulsion and the following requirements shall apply: 1. The emulsion shall be designated CQS-1h cationic quick setting emulsion and shall conform to the requirements of Cationic Type CSS-1h. 2.

    Get Price

  • SECTION 02505 EMULSIFIED ASPHALT SLURRY SEAL

    The slurry seal shall consist of a mixture of an approved emulsified asphalt, mineral aggregate, water and specified additives, proportioned, mixed and uniformly spread over a properly prepared surface.

    Get Price

  • HOT CHIP SEAL SPECIFICATIONS DESCRIPTION MATERIALS …

    HOT CHIP SEAL SPECIFICATIONS DESCRIPTION The Contractor shall furnish all labor, equipment, material, supplies, environmental protection, no ... the base asphalt binder for the emulsion shall be tested. The solubility of the base asphalt binder shall be greater than 99 percent. ... spreader to achieve the design application rate of the cover ...

    Get Price

  • SBR Latex Modified Emulsified Asphalt

    No traffic shall be permitted on uncovered emulsified asphalt binder. The emulsified asphalt binder shall not be applied until the loaded aggregate spreader is on hand ready to begin application of aggregate immediately, with sufficient truck loads of aggregate at the site to cover the length of the anticipated applications of emulsified asphalt binder.

    Get Price

  • Asphalt Distributor Truck | Chip Sealer | Micro Surfacing ...

    It applies asphalt emulsion, aggregate and additives to asphalt road for maintenance purposes. Slurry Seal / Micro-surfacing Paver, HGY5319TFC HGY5319TFC micro-surfacing paver is mainly used for improving road resistance, repairing potholes, and eliminating rutting as a solution for road rehabilitation.

    Get Price

  • Sealcoating Asphalt | Driveway Sealer | Sealcoat ...

    Polymer-Modified MasterSeal (PMM) Ultra Pavement Sealer is an environmentally friendly mineral filled asphalt emulsion pavement sealer blended with polymers and special surfactants for superior adhesion, flexibility and durability. PMM Ultra is a higher solids, faster drying pavement sealer designed to beautify and protect asphalt pavement.

    Get Price

  • ALABAMA DEPARTMENT OF TRANSPORTATION

    The Engineer will limit the length of placement ahead of the spreader (usually no more than 1000 feet) to reduce thepossibility of damage to the sealant. The Engineer will also require the placement of CQS-1HP emulsified asphalt, NTSS1HM emulsified asphalt, and Pavon™ far enough ahead of the asphalt spreader to allow the curing of the sealant.

    Get Price

  • Asphalt Spreader, Asphalt Spreader Suppliers and ...

    New mode Yuejin 5m3 asphalt spreader Asphalt distributor is a highly precise measuring asphalt spreader . It is often used to road construction and maintenance of bridges ,highways ,tunnels ,airports,country roads work. Asphalt distributor truck adopts asphalt spray bar fixed value display device ,nozzle auto-control device ,etc.

    Get Price

  • Bitumen Spreader, Bitumen Spreader Suppliers and ...

    Alibaba.com offers 804 bitumen spreader products. About 45% of these are pavers, 7% are other construction machinery, and 1% are fertilizer spreaders. A wide variety of …

    Get Price

  • Cationic very rapid setting polymer modified chip seal ...

    and curing of the emulsion to ensure strong embedment and bonding of the chip to the asphalt binder and the binder to the pavement surface. The waiting time for proper setting and curing of the emulsion is a period during which there is a risk of flying chip damage and traffic delays to the traveling public.

    Get Price

<< Previous: Road pavement repair
>> Next: 120 hp 6000 liter asphalt distributor